Carmeuse Lime Inc Metal/Non-Metal

EMPLOYEE WAS RE-INSTALLING TANK LOADING SPOUT WHEN DUST FELL FROM ABOVE AND GOT IN BOTH EYES.

WHILE LOADING BAGS OF LIME DUST ENTERED EMPLOYEES EYES.

EE STEPPED ON A STONE WHILE DECENDING STAIRS ANDSLIPPED, LANDING ON LEFT LEG.

WHILE RAKING IN PIT EMPLOYEE SLIPPED AND LANDED ON HIS KNEES ON THE STAIRS LEADING INTO PIT. NO RESTRICTIONS ORDERED BUT BECAME LOST TIME 1/15.

EMPLOYEE WAS REMOVING SCRAP STEEL FROM COOLER PIT WITHOUT THE USE OF PPE (GLOVES) AND SUSTAINED A CUT ON THE PALM OF HIS HAND. FOUR STITCHES WERE REQUIRED.

TRIPPED OVER I-BEAM LYING ON THE FLOOR.

EE WAS SPLICING A CONVEYOR BELT WHEN HE LOST HIS FOOTING AND FELL ABOUT 2' TO THE GROUND.

CUTTING A PIECE OF OVERHEAD METAL W/TORCH WHEN A NICKEL SIZE PIECE OF HOT SLAG FELL DOWN SLEEVE AND BURNED RIGHT WRIST.

EE WAS DESCENDING THE END LOADER BY WAY OF THE ATTACHED LADDER WHEN HE LOST HIS FOOTING AND FELL TO THE GROUND FROM ABOUT THE SECOND TO LAST RUNG, LANDING ON HIS BACKSIDE.

EE WAS SHOVELING LIME WHEN HE REPORTED FEELING PAIN IN HIS BACK.

EE WAS CLEANING OUT CASTABLES OUT OF VIBRATOR COOLER WHEN SOME OF IT FREED & SPLASHED UP IN HIS FACE. EE WAS WEARING GOGGLES.

EE WAS TIGHTENING A SHAFT WITH A SIX INCH PIPE WRENCH WHEN PIPE WRENCH SLIPPED AND FELL ON EE'S RIGHT SHOULDER.

EE WAS OILING #5 SCREEN WHEN LIMEDUST GOT INTO HIS R EYE. WAS WEARING SAFETY GLASSES.

EE WAS LOWERING NEW HEAD PULLEY ON #8 CONVEYOR INTO POSITION WHEN IT DROPPED AND HIS RIGHT HAND AND INDEX FINGER WAS PINCHED UNDER IT.

EE WAS WORKING BENT OVER, HARD HAT FELL OFF, EE STOOD UP TO PUT HARD HAT BACK ON, AND HIT HEAD ON STEEL BAR OVERHEAD.

EE STATES THAT WHILE LOADING TRUCKS, HE INHALED SOME LIMEDUST AND BEGAN TO FEEL IRRITATION AFTER HIS SHIFT.

EE WAS SHOVELING DUST AT #3 BELT WHEN HE STATES THAT HE FELT PAIN IN HIS LOWER BACK.

EMPLOYEE OPENED KILN DOOR & LIME DUST CAUSED CHEMICAL BURN TO LEFT EYE.

EMPLOYEE WAS WALKING THROUGH PLANT WHEN WIND BLEW LIMEDUST INTO EYES. NOTE: HAD SAFETY GLASSES ON.

EMPLOYEE WAS RAKING CHUNKS OF LIME OUT OF THE KILN WHEN DUST FLEW UP AND ONTO EMPLOYEE. NOTE: EMPLOYEE WAS WEARING SAFETY GLASSES & FACE SHIELD.

EE WAS ATTEMPTING TO PUT THE ID FAN TO FLUID DRIVE COUPLING BACK TOGETHER. HE WAS HOLDING THE COUPLING W/L HAND & HITTING IT W/ A HAMMER WHEN HE STRUCK HIS LEFT 4TH FINGER W/ THE HAMMER.

EMPLOYEE WAS LIFTING BUCKET OF BRICK SHIMS WHEN HE FELT PAIN IN STOMACH. NOTE: EMPLOYEE WENT TO CLINIC 1/9/02.

EMPLOYEE WAS WORKING ON DISCHARGE SEAL OF KILN WHEN LIME FELL OFF THE TOP OF KILN & WENT INTO HIS EYES. SAFETY GLASSES WERE WORN.

EMPLOYEE WAS COMING DOWN STAIRS FROM FLUEDUST SILO WHEN LIME BLEW INTO HIS RIGHT EYE.

DRIVE HOOKUP HOSE TRAILER WHICH LOOKS LIKE IT WAS HIT WITH HAMMER AND BEATEN ON, IN RESULT WHEN HE TRIED TO UNLOAD, HIS HOSE CAME APART IN RESULT LIME WENT ON HIM AND ALL OVER GROUND.

EMPLOYEE WAS ASSISTING IN CLEARING A BLOCKAGE IN THE MULTI COND PIPE AT THE REAR OF THE KILN WHEN LIME DUST BLEW UP UNDER HIS SAFETY GLASSES ANDINTO HIS EYES.

EMPLOYEE WAS FOUND LYING ON FLOOR UNRESPONSIVE, EMPLOYEE BECAME RESPONSIVE APPROX TEN MINUTES LATER AND STATED THAT HE HAD FALLEN DOWN THE SHIPPING STAIRS FROM ABOUT HALF WAY UP. HE STATED THAT ONLY HIS PREVIOUSLY INJURED LEG HAD PAIN.

EE WAS COMING DOWN STEPS AND DID NOT NOTICE BOTTOM STEP WAS MISSING, WHEN HE STEPPED DOWN HE JOLTED HIS BACK.

EMPLOYEE TOOK OFF SAFETY GLASSES TO WIPE SWEAT OFF OF THEM AND SWEAT/LIME DRIPPED INTO HIS EYES.

WHILE INSTALLING ON AIR CONDITIONER, IT TILTED AND SLID. EMPLOYEE GRABBED THE TOP AND THE METAL CUT HIS FINGER.

WHILE CUTTING WITH TORCH(WELDING) EE BURNED HIS EYES.

EMPLOYEE WAS WORKING IN COOLER AREA WHEN SOME LIME DUST FELL INTO HIS BOOTS CAUSING BURNS TO BOTH FEET.

EMPLOYEE WAS OFF LOADING 4'X 8' X 3/16" STEEL SHEETS W/FORK TRUCK, THE SLINGS SLIPPED OFF THE FORK TRUCK CAUSING PART OF THE STEEL PLATES TO LAND ON HIS LEFT FOOT.

EE WAS PUSHING STONE OFF BELT WITH LEGS AND PULLED MUSCLE IN RIGHT THIGH.

EMPLOYEE WAS INSPECTING REAR SEAL OF KILN WHEN WIND BLEW PIECE OF LIME INTO EYE. (WAS WEARING SAFETY GLASSES AT THE TIME).

EE WAS STEPPING OFF A PALLET WHEN HE STEPPED DOWN INTO A HOLE AND TWISTED HIS LEFT ANKLE.

EMPLOYEE WAS LIFTING 50 LB BAGS OF LIME HEN HE STRAINED HIS LOWER BACK.

EMPLOYEE WAS REACHING FOR AN OIL DIP STICK ON THE LOADER WHEN HE FELT A STRAIN IN HIS BACK.

EMPLOYEE STEPPED IN A GROUND HOLE WHILE WALKING AND TWISTED HIS ANKLE.

EMPLOYEE WAS USING CHAIN PULLS AND COME-A-LONGS TO CHANGE A ROLL IN THE COAL MILL WHEN HE FELT PAIN IN HIS SHOULDERS.

EMPLOYEE WAS CHANGING BAGS IN THE BAG HOUSE, AS HE PULLED A FULL BAG OF DUST OUT HE FELT PAIN IN HIS RIGHT KNEE.

EMPLOYEE WAS CHANGING BAGS IN COMPARTMENT #7 OF TE BAGHOUSE WHEN HE FELT A STRAIN IN HIS BACK.

EMPLOYEE WAS MOVING GRATES & SLIPPED & FELL ONTOSTEEL BEAM INJURING HIS BACK & LEFT SIDE.

EMPLOYEE WAS RAKING GRATE ON KILN WHEN LIME BLEWINTO HIS EYE. HE WAS WEARING SAFETY GLASSES.

EMPLOYEE WAS LIFTING OILING BUCKET WHEN HE FELT A PAIN IN HIS BACK.

EMPLOYEE WAS CHANGING VIBRATOR MOTOR WHEN THE WRENCH SLIPPED CAUSING HIS FINGER TO GET SMASHED.